2004 Gmc Topkick Recalls

The defect

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE GALVANIZED STEEL TAILGATE SUPPORT CABLES THAT RETAIN THE TAILGATE IN THE FULL OPEN (HORIZONTAL) POSITION MAY CORRODE, WEAKEN, AND EVENTUALLY FRACTURE. IF BOTH CABLES FRACTURED, THE TAILGATE WOULD SUDDENLY DROP AND STRIKE THE TOP SURFACE OF THE REAR BUMPER.

The risk

ANYONE SITTING OR STANDING ON THE HORIZONTAL SURFACE OF THE TAILGATE WHEN BOTH CABLES FRACTURED COULD BE INJURED BY FALLING FROM THE TAILGATE. ON VEHICLES THAT HAVE HAD THE BUMPER REMOVED, THE TAILGATE MAY DROP EVEN LOWER. ADDITIONALLY, IF THERE IS CARGO ON THE TAILGATE THE CARGO MAY FALL OFF IF THE SUPPORT CABLES FRACTURE.

The fix

DEALERS WILL REPLACE THE CABLES. INTERIM OWNER NOTIFICATION BEGAN ON APRIL 7, 20004. THE RECALL BEGAN ON SEPTEMBER 24, 2004, WHEN REPLACEMENT PARTS WERE AVAILABLE, AND WILL CONTINUE THROUGH OCTOBER 29, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463, OR VISIT WWW.MYGMLINK.COM, AND ENTER YOUR VEHICLE IDENTIFICATION NUMBER.

The defect

CERTAIN 2003-2005 MODEL YEAR 4500/5500 SERIES CHEVROLET KODIAK, SCHOOL BUS CHASSIS, AND GMC TOPKICK VEHICLES; AND 2003-2004 MODEL YEAR GMC SCHOOL BUS CHASSIS VEHICLES EQUIPPED WITH AN 8.1L ENGINE AND HYDROMAX BRAKE SYSTEM. THE POWER STEERING HOSE MAY COME INTO CONTACT WITH A PORTION OF THE INTERMEDIATE STEERING SHAFT. A HOLE COULD BE WORN IN THE HOSE AND A LOSS OF HYDRAULIC FLUID WOULD OCCUR.

The risk

IF THERE IS SUFFICIENT AMOUNT OF FLUID LOSS, THE DRIVER WILL HEAR A NOISE FROM THE POWER STEERING PUMP, THE BRAKE WARNING LIGHT AND WARNING TONE WILL ACTIVATE. INCREASED EFFORT MAY BE REQUIRED FOR STEERING AND BRAKING, INCREASING THE RISK OF A CRASH.

The fix

GM WILL NOTIFY ITS CUSTOMERS AND DEALERS WILL REROUTE THE POWER STEERING HOSE. IF THE STEEL BRAIDING OF THE HOSE IS EXPOSED, DEALERS ARE TO REPLACE THE HOSE FREE OF CHARGE. THE RECALL BEGAN ON JULY 12, 2005. OWNERS MAY CONTACT CHEVROLET AT 800-630-2438 OR GMC AT 866-996-9463.

The defect

ON CERTAIN MEDIUM DUTY TRUCKS EQUIPPED WITH ZF MODEL 8018 STEERING GEARS, THE STEERING GEAR MAY HAVE BEEN PRODUCED INCORRECTLY. A STEERING GEAR WITH THIS CONDITION MAY PRODUCE THE FEELING OF HITTING A CURB AND A CRACKING OR PINGING SOUND WHEN THE STEERING WHEEL IS TURNED.

The risk

THE STEERING WHEEL POSITION MAY BE OFF-CENTER AND INCREASED EFFORT MAY BE REQUIRED WHEN TURNING, INCREASING THE RISK OF A CRASH.

The fix

DEALERS WILL INSPECT FOR CERTAIN DATE CODES AND VERIFY THE MILEAGE ON STEERING GEARS AND REPLACE GEARS AS NECESSARY. THE RECALL BEGAN ON OCTOBER 25, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR ISUZU AT 1-800-255-6727.

Reported April 10, 2007 by GENERAL MOTORS CORP.

The defect

CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.

The risk

IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.

The fix

DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.

Reported August 2, 2005 by GENERAL MOTORS CORP.

The defect

ON CERTAIN TRUCKS, THE SWITCH RETAINER HOLDING THE BRAKE BOOSTER PUSH ROD AND THE BRAKE PEDAL TOGETHER COULD BE MISSING.

The risk

THIS COULD CAUSE THE PUSH ROD AND PEDAL TO SEPARATE, RESULTING IN A LOSS OF FOUNDATION BRAKES AND INCREASING THE RISK OF A CRASH.

The fix

DEALERS WILL INSPECT AND INSTALL A NEW RETAINER IF MISSING. OWNER NOTIFICATION BEGAN MARCH 5, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT GMCICT AT 1-800-862-4389.

Reported October 3, 2004 by GENERAL MOTORS CORP.